2 Ton Biogas Fired Steam Boiler

In the process of increasing the outlet temperature of the furnace of gas-fired boiler, the loss of boiler will increase, and the scaling in the water-cooled wall of the equipment will effectively reduce the heat transfer effect. This is likely to lead to an increase in the temperature of the wall of the water wall and the explosion of the tube of the wall of the water wall.

Third, the maintenance and repair of gas condensing boilers.

For condensing boiler maintenance and repair on a regular basis, it is the main reason affecting the quality of its work. To make the boiler run time regular inspection and maintenance, but also to the boiler outage for maintenance, so as to guarantee the normal operation of the boiler when used again in order to maintain a long service life of the boiler.

Coal-fired boiler not only seriously polluted air, which produces a large amount of waste water sludge can also cause serious water pollution and soil contamination. To protect the city of Tongren green water blue sky, since 2014, led by the city of Tongren City, Guizhou Bureau of Quality Supervision, of 10 steam tons / hour within built-up areas and Tongren City High-tech Zone, Economic Development Zone, Tai Lung range and below, in Guizhou tobacco industry limited liability company Tongren cigarette factory, Tongren City, drug rehabilitation centers, Tongren Wantong construction and development Co., Ltd. and other 36 enterprises of coal-fired boilers to carry out an intensive diagnostic investigation. One by one on the ground to verify the registration, and the companies signed an undertaking to ban coal-fired boilers eliminated; to effectively reduce the burden on enterprises, according to the spirit of the document, to take the initiative within the time limit or eliminate the use of coal-fired boiler unit to switch to clean energy, the after review and acceptance Municipal Environmental Protection Bureau, according to the amount of coal-fired boilers hour evaporation reward, award criteria tons of steam per 30,000 yuan subsidy.

Up to now, the city of Tongren out of 36 coal-fired boiler units, a total of 43.051 tons of steam, an award subsidies 1,291,530 yuan, so far, the city of Tongren jurisdictions total phase-out of all coal-fired boilers, and lay a good foundation for the creation of ecological civilization demonstration area.

Coal-fired boiler combustion safety, the furnace explosion hazard unlikely to occur. The gas-fired boilers within the boundaries of explosive concentrations encountered fire will explode, more dangerous.